Engineering Technologies and Systems - 04. Razvorotnev A.S., Gavrichenkov Yu.D. Technology for Monitoring and Control of Air Flows Inside Metal Silos during Grain Storage

UDK 631.243.3:664.72

DOI: 10.15507/2658-4123.030.202002.232-253

Technology for Monitoring and Control of Air Flows Inside Metal Silos during Grain Storage

Alexandr S. Razvorotnev
Senior Researcher of All-Russian Research Institute of Grain and Its Processing Products (11 Dmitrovskoye Shosse, Moscow 127434, Russia), Ph.D. (Engineering), Associate Professor, Researcher ID: AAH-1423-2019, ORCID: https://orcid.org/0000-0002-3957-041X, This email address is being protected from spambots. You need JavaScript enabled to view it.

Yuri D. Gavrichenkov
Senior Researcher of All-Russian Research Institute of Grain and Its Processing Products (11 Dmitrovskoye Shosse, Moscow 127434, Russia), Ph.D. (Engineering), Associate Professor, Researcher ID: AAG-8142-2019, ORCID: https://orcid.org/0000-0001-5590-8997, This email address is being protected from spambots. You need JavaScript enabled to view it.

Introduction. Preservation of grain crops in flat-bottomed metal silos is not possible without monitoring and control of air flows in the internal volume. In the silos with uncontrolled air flows, there is a redistribution of moisture and additional moistening of the grain surface layer that leads to losses of about 2% of grain. The aim of this work is to develop a technology for preventing the grain surface layer from humidifying during storage in metal silos.
Materials and Methods. Under laboratory conditions, aerodynamic parameters of wheat and soybean grains were determined in the range of filtration rates less than 0.15 m/s. In metal silos, with a capacity of 2,000, 3,000 and 10,000 t, the temperature and relative humidity of the air inside at the top of the silos and outside were measured simultaneously. The temperature and relative humidity measurement period was 30 min for two and five months. Autonomous recorders were used for measurement.
Results. A new objective standard of grain ventilation is proposed ‒ minimum (critical) filtration rate, which ensures moisture removal outside the silo. The analytical studies produced an equation for calculating the weighted average filtration rate of air leaving the grain mass. The total air flow rate corresponding to the weighted average filtration rate will provide a filtration rate of at least critical over the entire surface and will exclude moisture settling. The periods of air saturation with moisture up to 100% in the supervisory space under the roof of the silo have been determined experimentally. The mechanism of heat emission up to the silo roof space from the depth of grain mass during storage has been clarified.
Discussion and Conclusion. The algorithm for safe active ventilation of grain and roof space in metal silos is proposed. Limit values of relative humidity of atmospheric air are recommended, the use of which will exclude humidification of grain mass when ventilating actively in the range of temperature difference between grain and atmosphere up to 30 °С and more. The obtained data can be used by mechanical engineers in the manufacture of metal silos and by grain producers in the operation of the said silos.

Keywords: metal silo, ventilation, grain storage, self heating, humidification, relative humidity, temperature

For citation: Razvorotnev A.S., Gavrichenkov Yu.D. Technology for Monitoring and Control of Air Flows Inside Metal Silos during Grain Storage. Inzhenerernyye tekhnologii i sistemy = Engineering Technologies and Systems. 2020; 30(2):232-253. DOI: https:// doi.org/10.15507/2658-4123.030.202002.232-253

Acknowledgements: The authors would like to thank V. F. Sorochinskiy, D.Sc. in Engineering, for his assistance in choosing the research direction and the Chief Technologist of the BioTechnologies company G. D. Dikova for her help in conducting research in industrial conditions.

Contribution of the authors: A. S. Razvorotnev – literature analysis, text editing; Yu. D. Gavrichenkov – literary data analysis, scientific guidance, data processing, article writing.

All authors have read and approved the final manuscript.

Received 09.10.2019; revised 06.12.2019; published online 30.06.2020

REFERENCES

1. Feydengold V.B. Russia’s Need for Grain Storage Facilities. Expert Assessment. Kombikorma = Compound Feeds. 2019; (6):82-86. (In Russ.) DOI: https://doi.org/10.25741/2413-287X-2019-06-2-071

2. Kumar D., Kalita P. Reducing Postharvest Losses during Storage of Grain Crops to Strengthen Food Security in Developing Countries. Foods. 2017; 6(8):1-22. (In Eng.) DOI: https://doi.org/10.3390/foods6010008

3. Carrera-Rodríguez M., Martínez-González G.M., Navarrete-Bolaños J.L. Transient Numerical Study of the Effect of Ambient Temperature on 2-D Cereal Grain Storage in Cylindrical Silos. Journal of Stored Products Research. 2011; 47(2):106-122. (In Eng.) DOI: https://doi.org/10.1016/j.jspr.2011.01.006

4. Hammami F., Mabrouk S.B., Mami A. Modelling and Simulation of Heat Exchange and Moisture Content in a Cereal Storage Silo. Mathematical and Computer Modelling of Dynamical Systems. 2016; 22(3):207-220. (In Eng.) DOI: https://doi.org/10.1080/13873954.2016.1157823

5. Modular Aeration Assembly for Grain Bins: Patent 8720079 USA. No. 20120047762; appl. 26.08.2010; publ. 13.05.2014. Available at: https://patents.justia.com/patent/8720079 (accessed 20.04.2020). (In Eng.)

6. Chen S., Wu W., Xu Y., et al. The Experimental Research on Grain Storage Heat and Moisture Transfer. In: International Conference on Advances in Mechanical Engineering and Industrial Informatics (AMEII 2015). 2015. Pp. 28-33. Available at: https://scholar.google.com/scholar?hl=ru&as_sdt=0%2C5&q=The+Experimental+Research+on+Grain+Storage+Heat+and+Moisture+Transfer+&btnG= (accessed 20.04.2020). (In Eng.)

7. Olatunde G., Atungulu G.G., Sadaka S. CFD Modeling of Air Flow Distribution in Rice Bin Storage System with Different Grain Mass Configurations. Biosystems Engineering. 2016; 151:286-297. (In Eng.) DOI: https://doi.org/10.1016/j.biosystemseng.2016.09.007

8. Binelo M.O., Faoro V., Kathatourian O.A., et al. Airflow Simulation and Inlet Pressure Profile Optimization of a Grain Storage Bin Aeration System. Computers and Electronics in Agriculture. 2019; 164. (In Eng.) DOI: https://doi.org/10.1016/j.compag.2019.104923

9. Razvorotnev A.S., Gavrichenkov Yu.D. Evaluation of Metal Silos Efficiency in Terms of Specific Power Consumption for Grain Ventilation of Different Crops. Khleboprodukty = Bakery Products. 2018; (10):53-55. (In Russ.) DOI: https://doi.org/10.32462/0235-2508-2018-0-10-53-55

10. Lopes D.C., Neto A.J.S., Júnior R.V. Comparison of Equilibrium Models for Grain Aeration. Journal of Stored Products Research. 2015; 60:11-18. (In Eng.) DOI: https://doi.org/10.1016/j.jspr.2014.11.001

11. Panigrahi S.S., Singh Ch.B., Fielke J.M. Effect of Mediterranean Climatic Condition during Aeration and Silo Wall Coating in On-Farm Grain Storage in South Australia. American Society of Agricultural and Biological Engineers. 2019. (In Eng.) DOI: https://doi.org/10.13031/aim.201900976

12. Razvorotnev A.S., Gavrichenkov Yu.D. Air Flow Control inside the Metal Silo during Grain Storage. Khleboprodukty = Bakery Products. 2019; (11):60-63. (In Russ.) DOI: https://doi.org/10.32462/0235-2508-2019-28-11-60-63

13. Razvorotnev A.S., Gavrichenkov Yu.D., Kechkin I.A. Modes of Storage and Ventilation of Wheat Grain in Metal Silos of Large Capacity. Khleboprodukty = Bakery Products. 2017; (11):57-59. Available at: https://khlebprod.ru/260-zhurnaly-2017/11-17/3032-rezhimy-khraneniya-i-ventilirovaniya-zerna-pshenitsy-v-metallicheskikh-silosakh-bolshoj-vmestimosti (accessed 20.04.2020). (In Russ.)

14. Gavrichenkov Yu.D., Razvorotnev A.S., Kechkin I.A., et al. Change of the Acid Number of Wheat Grain Fat While Stored in Laboratory Conditions. Food Systems. 2019; 2(2):27-30. (In Russ.) DOI: https://doi.org/10.21323/2618-9771-2019-2-2-27-30

15. Navarro Sh., Noyes R.T. The Mechanics and Physics of Modern Grain Aeration Management. Boca Raton: CRC Press; 2001. 672 p. (In Eng.)

16. Francisco N.-M. Simulation of the Temperature of Barley during Its Storage in Cylindrical Silos. Mathematics and Computers in Simulation. 2019; 157:1-14. (In Eng.) DOI: https://doi.org/10.1016/j.matcom.2018.09.004

17. Grain Conditioning System and Methodology: Patent 9885520 USA. Appl. 03.08.2016; publ. 06.02.2018. Available at: https://patents.google.com/patent/US9885520B1/en (accessed 20.04.2020). (In Eng.)

18. Bradna J., Šimon J., Hájek D., et al. The Impact of Weather Conditions on Microclimate in Storage Facilities. Agronomy Research. 2018; 16(4):1580-1589. (In Eng.) DOI: https://doi.org/10.15159/AR.18.178

19. Sorochinskiy V.F. Change of Temperature of the Wall Layer of Grain in Metal Elevators. Khranenie i pererabotka selhozsyirya = Storage and Processing of Farm Products. 2016; (4):13-16. Available at: https://vniiz.org/science/publication/article-151 (accessed 20.04.2020). (In Russ.)

This work is licensed under a Creative Commons Attribution 4.0 License.